Separate names with a comma.
Remove this and inspect the wiring and mechanism [IMG]
I fear you may have damaged a module or two due to initial over torquing the terminals. Man, that sucks.
Welcome aboard. Yes, inverter pump needs replacing. do it sooner than later as it will damage the inverter which is not cheap. As far as the...
Ah poop, okay, well you got the Reaktor on it's way so you are headed in the right path. That is awesome news about the seller of the donor. Very...
That is awesome news! Break a Leg brother, we are here to help :D
Do you have a motorcycle mode on your charger? Once a month I charge my spares on my C-tek 3300 at motorcycle mode and it will stay below 9 volts...
Holy-Smokes, that is pretty bad. I would try to test charge a cell and see if it holds a charge and pass a load test using the rig previously...
Remember use BRASS wire wheel Steel will eat the copper tabs. Use Eye protection and gloves.
That'll do the trick but you will still need to remove the bus bars to test each individual cell to identify good from bad. OP, you could build...
Agreed, hard to tell by the exterior, but I bet you can rebuild your existing HV battery from part from this one if come cells are still good. We...
You could keep 1/2 dozen cells as back up, sell the rest at $20-35 each and make a profit on the remaining good cells to help off set the cost...
Just be very careful of those sensors, they are ridiculously thin and brittle Try to get some contact cleaner down the wires if you are going to...
Wow, that is a good price If anything you could scavenge the good cells
If seller is willing to allow you to remove the cover you can tell how bad the bus bars are and if there is any swelling of the cells or evidence...
Oh yes, but I would still change the front bus bar so you will not have future issues and clean that rear bus bar I used a wire wheel on the...
Those bus bars look suspect, especially with all that green patina, that could definitely cause poor continuity. Also, it may not look it but...
Don't worry OP, 2nd time around is much easier, just don't skip any safety pre-cautions.
Where in Cali are you? You really need or borrow a Mini-vci with TIS ( Prius Aware Code Reader ) to properly diagnose the HV battery's state....
Oh good, those are relatively an easy fix.
I would like to know too, but I doubt it as I recall the anticipated life of the HV battery was 8 years???
