1. Attachments are working again! Check out this thread for more details and to report any other bugs.

My Gas Motor turns on as soon as touch the accelerator

Discussion in 'Gen 2 Prius Fuel Economy' started by grccmetech, Feb 12, 2018.

Tags:
  1. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    As soon as I push the gas, even if I lightly tap it, the gas engine turns on. its effecting my gas mileage I am currently getting 22-32 depending on how much highway driving I do. I have replaced both o2 sensors because it was throwing a code and acting up terribly, but now its good except the electric motor doesn't engage without the gas motor engaging aswell. I also changed the fuel injectors spark plugs and the oil. finally swapped 12v battery but even the new battery still is at 11.6V after overnight the old one was at 11V so I don't know if that has anything to do with the inverter or not. please help
     
    #1 grccmetech, Feb 12, 2018
  2. SFO

    SFO Senior Member

    Joined:
    Feb 7, 2017
    5,302
    4,241
    0
    Location:
    Northern California
    Vehicle:
    2007 Prius
    Model:
    N/A
    Welcome to PriusChat!!

    How many miles on this vehicle?

    How did you read the thrown codes previously?
     
    #2 SFO, Feb 12, 2018
    Raytheeagle likes this.
  3. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    273k I read it with a snap on scanner
     
    #3 grccmetech, Feb 12, 2018
  4. Drafty01

    Drafty01 Junior Member

    Joined:
    Jan 18, 2013
    42
    6
    0
    Location:
    Auckland, New Zealand
    Vehicle:
    2006 Prius
    Model:
    N/A
    What voltage does your 12V battery charge at? Should be about 14.0 to 14.5V.
    11.6V is basically flat, and will likely ruin it in a short time.
     
    #4 Drafty01, Feb 12, 2018
  5. fotomoto

    fotomoto Senior Member

    Joined:
    Apr 22, 2009
    5,608
    3,787
    0
    Location:
    So. Texas
    Vehicle:
    Other Hybrid
    This.

    Sounds like the HV side of the equation is not working properly or possibly at all. Usual suspects: inverter, inverter pump and/or HV battery weak/failed.
     
    #5 fotomoto, Feb 12, 2018
  6. Dxta

    Dxta Senior Member

    Joined:
    Nov 7, 2016
    1,932
    767
    0
    Location:
    Lagos
    Vehicle:
    2008 Prius
    Model:
    II
    Your HV battery pack might be heading South already. No matter what you do, until the HV part of the equation is sorted out, before you'd get a relief.
     
    #6 Dxta, Feb 12, 2018
  7. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    ya i definitely suspect the hv battery. my aux battery does charge at 14.1V. The inverter pump is working, and the inverter itself has to be working because the car drives fine for the past 3 months. I happen to have access to a snap on scanner so I can read the voltages of the individual cells in the hv battery. i am planning on testing them after letting it sit 24hrs to see if i can get away with replacing just a couple modules. my question is, is there any other way to test the hv battery?
     
    #7 grccmetech, Feb 15, 2018
  8. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    110,129
    50,045
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    i think torque pro is a decent prius scanner.

    but i have concerns about the second 12v battery you installed. is it new? did you check the voltage before installation?
     
    #8 bisco, Feb 15, 2018
  9. TMR-JWAP

    TMR-JWAP Senior Member

    Joined:
    Aug 12, 2016
    6,404
    6,062
    0
    Location:
    Columbia, SC
    Vehicle:
    2007 Prius
    Model:
    Touring
    The Prius is typically pretty darn good at coding an HV battery when it's getting to be time to replace it. If there's no HV battery codes, I don't know that I would focus a lot of energy or money in that direction. If your brand new 12v battery is 11.6v, I think I'd rectify that situation first. Put a low amp charger on it and top it off. My manual says it should be limited to 3.5 amps.

    Start with the obvious things first. Tearing into the HV battery with no codes seems like unwarranted business to me.
    Get a good 12v charge, re-install the battery, and test it out. Just keep in mind you've put new O2 sensors in, and cleared all the ecu maps when the 12 v was off. And I'm sure the weather is cold as a witches t*t where you are. None of those things are immediate positive things in your corner. What injectors/plugs and oil did you install? Is Techstream available to you?
     
    #9 TMR-JWAP, Feb 15, 2018
    jerrymildred likes this.
  10. uart

    uart Senior Member

    Joined:
    Sep 7, 2009
    4,215
    1,202
    0
    Location:
    Australia
    Vehicle:
    2005 Prius
    The main things I've noticed that can cause the engine to be a bit "hair triggered" in wanting to start like that are:

    1. A weak HV battery.
    2. Low state of charge (4 or less bars on the energy monitor screen).
    3. Very high temperatures (including blocked rear cooling fan).
    4. Very low temperatures.

    Before worrying too much about number 1 on the list, check if any of the others are applicable. Have you checked the rear cooling fan for blockages (dust,fur,lint etc).
     
    #10 uart, Feb 16, 2018
  11. Astrong1984

    Astrong1984 New Member

    Joined:
    Jan 30, 2018
    12
    2
    0
    Location:
    Castle Rock Colorado
    Vehicle:
    2009 Prius
    Model:
    Touring
    This may sound rudimentary, but do you have the heat on, and is it cold outside? I am in Colorado and when it is cold out, both of my Gen2s act that way.
     
    #11 Astrong1984, Feb 18, 2018
    Mendel Leisk likes this.
  12. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    i am going to test the HV cells today after letting them sit over night. and ill test the12v battery before returning it.
     
    #12 grccmetech, Feb 22, 2018
  13. Lucifer

    Lucifer Senior Member

    Joined:
    Aug 23, 2015
    1,014
    486
    0
    Location:
    Nh
    Vehicle:
    2017 Prius Prime
    Model:
    Plug-in Advanced
    It' an 06, the traction battery is 12 years old, just buy a new from Toyota traction battery and get five years of 50+ mpg, and make sure that the plugs you put in are good, your mileage is really low, missing cylinder low.
    Last word was Toyota is selling the traction for 2000$, not a bad deal, did you buy a new 12v or swap a used one?
    Is your air pressure 40, is your emergency brake cable binding?
     
    #13 Lucifer, Feb 22, 2018
  14. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    i let the car sit overnight and all the voltages are within .2v. i tested the 12v out of the car and it passed the test. im starting to think that the average mpg is off. i recorded my miles when i filled up so i will do the math at the end of the week. my battery fan works too btw i did a test on the snap on scanner
     

    Attached Files:

    #14 grccmetech, Feb 22, 2018
  15. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    i will add that at 40% SOC the volts were at 15 i dont know if that has anything to do with anything
     
    #15 grccmetech, Feb 22, 2018
  16. SFO

    SFO Senior Member

    Joined:
    Feb 7, 2017
    5,302
    4,241
    0
    Location:
    Northern California
    Vehicle:
    2007 Prius
    Model:
    N/A
    That scanner looks pretty advanced, like to the point of being able to scan/log/play back live data.

    Can you scan while putting a load on the HV battery?
     
    #16 SFO, Feb 22, 2018
  17. grccmetech

    grccmetech New Member

    Joined:
    Feb 12, 2018
    7
    0
    0
    Location:
    grand rapids mi
    Vehicle:
    2006 Prius
    Model:
    II
    ya i push the gas or put it in reverse not much seems to happen with the voltages
     
    #17 grccmetech, Feb 22, 2018
  18. golfmk681

    golfmk681 Active Member

    Joined:
    Aug 7, 2017
    262
    105
    0
    Location:
    los angeles, ca
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    How are you guy's MPG when its super cold? Should we see low 30s when the car typically gets 40s mpg in regular weather?
     
    #18 golfmk681, Feb 22, 2018
    audiodave likes this.
  19. audiodave

    audiodave Active Member

    Joined:
    Feb 3, 2017
    788
    269
    0
    Location:
    US
    Vehicle:
    2004 Prius
    Model:
    Five
    Trickle charger the 12volt couple times a week. Car charger sucks.


    Posted via the PriusChat mobile app.
     
    #19 audiodave, Feb 23, 2018
  20. audiodave

    audiodave Active Member

    Joined:
    Feb 3, 2017
    788
    269
    0
    Location:
    US
    Vehicle:
    2004 Prius
    Model:
    Five
    Did you notice improvements in power after the injectors where replaced?

    Posted via the PriusChat mobile app.
     
    #20 audiodave, Feb 23, 2018
(You must log in or sign up to post here.)