1. Attachments are working again! Check out this thread for more details and to report any other bugs.

How best to touch up scratches?

Discussion in 'Gen 2 Prius Technical Discussion' started by molgrips, Aug 9, 2006.

  1. molgrips

    molgrips Member

    Joined:
    Jul 6, 2006
    199
    3
    0
    So I've got a scratch on the back, near the boot opening. It's down to the primer, but not the metal. I've got the touch-up kit from Toyota, but I haven't had much success getting a repair that's close to invisible.

    I tried just painting the scratch, I also tried painting a wider area and wiping excess off using a solvent-soaked paper towel. This worked a bit but either it wiped all the paint away or, if I left it longer, it sort of polished the paint leaving a smooth shiny patch in my sparkly metallic paint.

    Have you guys got any tips? I've also got some chips in the bonnet which are round and down to the metal - these are very hard to fill in with paint...

    I'm a little reluctant to get the sandpaper out, in case I screw it up!
     
    #1 molgrips, Aug 9, 2006
  2. Tideland Prius

    Tideland Prius Moderator of the North
    Staff Member

    Joined:
    Oct 2, 2004
    45,024
    16,242
    41
    Location:
    Canada
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    if it's a light scratch, try waxing first.

    I have a deep scratch (most likely by a key or a knife) just above the PRIUS emblem on the hatch. It's about 1½" long and I cannot touch that up without making it obvious. I've done well with other chips and scratches though.
     
    #2 Tideland Prius, Aug 9, 2006
  3. curse

    curse New Member

    Joined:
    Jun 25, 2006
    36
    0
    0
    Here's what I have done for such minor touck-ups...
    1. Clean the immediate area with alcohol.
    2. Dip a toothpick into the touch-up paint to get only a small amount - not a drop.
    3. Transfer the paint into the scratch like a fine tipped pen, not like a brush. As long as the primer is intact, you are only trying to hide the primer color, not to completely fill the scratch or feather it into the surrounding area.
    Maybe not the best method, but I think that the more paint you apply or the wider you make the repair, the more obvious the repair will be.

    Good luck!
     
    #3 curse, Aug 10, 2006
  4. B Rad

    B Rad New Member

    Joined:
    May 18, 2006
    295
    1
    0
    <div class='quotetop'>QUOTE(Mark M. @ Aug 10 2006, 11:50 AM) [snapback]300887[/snapback]</div>
    After you do the above, take a small piece of 2000 wet sand paper and lightly rub the imediate area to bring the new paint down level with the original paint. Then go over the area with rubbing compound followed by a hand glaze and then wax. Be gentle......
     
    #4 B Rad, Aug 10, 2006
(You must log in or sign up to post here.)