Blown Engine

sorry to hear it.

what are you getting for estimates? new engine? salvage? how about repair?

call hometown hybrids in houston and ask them if they can recommend a mechanic

 

Sorry to hear your beloved Prius bite the dust. I would say if everything else is in good condition, at 2K fix it. at 5K forget it. Your estimate of 2K-5K is a really wide range. at 3-4K, it is going to be a tough decision. At 171,000 miles, you might be looking at more expensive repairs like traction battery even if you replace an engine.

 

These are Gen 4 engines available near your zip code based off the location in your profile. 150 or so for head gasket set, and 120 for head bolts. Install (or have installed) Gen 3 head (yours) on Gen 4 engine block. Any of the engines would function just fine in your car.

 

Most likely, the engine experienced a head gasket failure (not uncommon) and began consuming large amounts of coolant. The coolant caused hydrolocking which resulted in damage to the connecting rods. The connecting rods bent and were weakened. With some additional use, the connecting rods failed and the rod poked thru the block.

If you had stopped driving the car immediately after the misfire (which triggered the check engine light) then the engine may have been repaired.

At this point, unless you have resources to get this done without paying market price for the labor, I would junk the car and move on to something else.

 

You could maybe get an engine from a local self service junkyard. Look for a car with significant collision damage. The engines run about 260.00 and there are probably parts pullers around the yard that will pull a motor for 100 bucks. Rent a truck from Uhaul or home depot to get the motor to a shop. A local independent shop will probably charge 700 to put the motor in.

 

Too bad you won’t find a running Gen 3 engine in a junkyard for 260. Not with the oil burning, head gasket blowing reputation this engine has. The yard 5 miles from my house STILL has the running, actively leaking from the head gasket 245,000 mile motor I looked at in July of 2018. And they STILL want 1400 dollars for it. It’s basically a rebuildable core.

 

2011 Prius with 171,000 miles and a blown engine? Replace the car and move on.

 

My rule that I go by, when repairs exceed half of trade in, its time to move on. Trade in on a 3 in “Good” condition is shown here. It’s feasible for this car to be repaired for 1600 if DIY, 2400 if done somewhere. Given that an engine replacement is getting to be a common thing on the early Gen 3, it’s not going to hurt the final value. Fix it, drive it a year or two, and trade it off.

 

Your figures are not accurate. Black Book is auction price and Dealerships seldom give you that for trade ins. Even if they say they do...it's because they are jacking you somewhere else. Julia, unless your mechanic (uncle) is going to do the swap for free, with a low mile used engine of known good condition, that's remarkably low priced...move on to your next.