1. Attachments are working again! Check out this thread for more details and to report any other bugs.

2016 Prius c, Just drained both engine and inverter coolant. Only four quarts came out.

Discussion in 'Prius c Care, Maintenance and Troubleshooting' started by dubya, Apr 28, 2022.

  1. dubya

    dubya Junior Member

    Joined:
    Dec 10, 2016
    11
    0
    0
    Location:
    Hilo, Hi
    Vehicle:
    2016 Prius c
    Model:
    I
    Both reservoirs were full before draining, I also drained the engine reservoir. How to drain the other 3.3 quarts that are in there? Book says 5.6 engine capacity and 1.7 inverter , so 7.3 total. Thanks for any help.
     
    #1 dubya, Apr 28, 2022
  2. Mendel Leisk

    Mendel Leisk EGR Fanatic

    Joined:
    Oct 17, 2010
    56,675
    39,222
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Disconnect the lowest hose on the exhaust heat recovery unit?

    Repair Manual always says to remove the block drain bolt: at least on our 2010 that got me less than a 1/4 cup. And it was a production to get to.
     
    #2 Mendel Leisk, Apr 29, 2022
    PriusCamper likes this.
  3. dubya

    dubya Junior Member

    Joined:
    Dec 10, 2016
    11
    0
    0
    Location:
    Hilo, Hi
    Vehicle:
    2016 Prius c
    Model:
    I
    Hi Mendel, Thanks for the reply. Where is the heat recovery unit. I will be ordering a repair manual, what are people using, Climer, Haynes, or is the factory manual a must? Thanks
     
    #3 dubya, Apr 29, 2022
  4. PriusII&C

    PriusII&C Active Member

    Joined:
    Oct 15, 2013
    370
    130
    0
    Location:
    San Jose, California
    Vehicle:
    2012 Prius
    Model:
    II
    That's the amount of coolant I replaced when I did it: about a gallon.
     
    #4 PriusII&C, May 1, 2022
  5. Mendel Leisk

    Mendel Leisk EGR Fanatic

    Joined:
    Oct 17, 2010
    56,675
    39,222
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Just noticed you have a c. Assuming it also has this, I'd look just aft of the catalytic converter(s); it's part of the exhaust system, and you'll be seeing (coolant) hoses attached to it.
     
    #5 Mendel Leisk, May 1, 2022
  6. Lukey51

    Lukey51 Active Member

    Joined:
    Jan 11, 2020
    204
    108
    0
    Location:
    TN
    Vehicle:
    2012 Prius c
    Model:
    Two
    I followed this and all went well.

     
    #6 Lukey51, May 27, 2022
  7. Lukey51

    Lukey51 Active Member

    Joined:
    Jan 11, 2020
    204
    108
    0
    Location:
    TN
    Vehicle:
    2012 Prius c
    Model:
    Two
    Me too. No manual needed, IMHO.
     
    #7 Lukey51, May 27, 2022
  8. Matt H

    Matt H Active Member

    Joined:
    Nov 23, 2012
    164
    104
    0
    Location:
    Okinawa Japan
    Vehicle:
    2012 Aqua
    Model:
    N/A

    The book states the total system capacity, but there will always be a small amount of coolant left in the system. Heater core, etc. Toyota knows this, and it's the reason the second change interval is at about half of the original; 160,000km/7 years for the first and 80,000km/4 years for subsequent.

    However, if you changed the coolant IAW the video above, the reason you got so little is because you left some coolant in the radiator. There are two places it needs to be drained for the engine, and he only does the drain cock on the engine. There's also a drain cock on the left hand bottom of the radiator (transmission side). It's literally "Step A" in the service procedure.
     
    #8 Matt H, Jun 4, 2022
    9001MPG likes this.
  9. amahastpl

    amahastpl Junior Member

    Joined:
    Jun 21, 2020
    11
    6
    0
    Location:
    New Jersey
    Vehicle:
    2013 Prius c
    Model:
    Four
    same here, one gallon originally, then topped off about half a quart after driving around for a day
     
    #9 amahastpl, Dec 21, 2022
(You must log in or sign up to post here.)