2010 Toyota Prius FCD Inaccuracy

I'm just above 5,200 now, and I have very similar results.

Agreed.

I'm glad customer service knows about this, is looking into it and is being responsive. Let's hope this gets cleared up sometime soon. If I'm really getting 54MPG+ on a Prius V, I shouldn't be complaining at all. But the fact that the computer tells me I'm really getting 57MPG+ just isn't right (unless the ODO is really messed up).

Here's a chart showing that my variance really is narrowing in on 5%:



(The above jpeg is a bit degraded. A better view of it is available in the .pdf file listed below.)

 

Have either of you checked the speedometer mileage against a portable GPS? I wonder if it is the distance, the fuel flow, or both that's off? A gas pump could be off by quite a few percent but I doubt all of them are.

 

There are a couple of other threads on this, and everyone's seeing calculated mpg lower than displayed mpg.

In previous Toyota's I came to expect that the displayed mpg would be about 1.5 mpg higher than actual, and it was pretty consistent across two RX 330s, a Camry Hybrid, and a Highlander Hybrid.

Here I'm seeing the display read 1.5 to 3 mpg higher, with the gap getting wider the higher the mpg's. Just today I filled up with the display reading 53.2, and a calculated mpg of 50.2.

I can't complain about the actual mpg; I'm very happy there. I just wish the displayed mileage was closer to actual.

 

Following is copy of my post.
=====
Japanese G3 owners are also seeing 5-6% error.
I saw approx 10% error on the VW Golf.
Are there any vehicle which reports the exact same computer MPG as calculated MPG?

There are a lot of factors to produce computer MPG error, and a car manufacturers doesn't want to display worse computer MPG than calculated(actual) MPG.

A rumor says that Toyota engineers are going to display intentionally 5% better number on computer MPG for the Gen3 Prius.

Ken@Japan

 

My testing with a Garmin nuvi showed the indicated MPG was about 1 mph high at 50-70 mph but the trip meter average speed was accurate. Previous tests with my NHW11 showed the speed error is proportional to the milage error from different sized tires.

Bob Wilson

 

Hi Wayne (and Canadian Gen III owners);

Like Mike, I also submitted the issue to Toyota Canada Inc. last week notifying them of the issue and the need to have it addressed. I was informed they would look into it ASAP.

Cheers;

MSantos

 

Send the Toyota rep to this thread, Wayne. I'll keep updating the chart I posted above, but it is a slow thing when fill-ups are so far apart!

I'm thinking the difference is settling in at 5% for me. Ten tanks and 5,000 miles seems like a decent enough sample set.

BTW: Who did you find that would paint Blue Moon Metallic on your new 2010?

 

The error between calculated and indicated on my '09 seems to follow the same trend. Typically my numbers differ by 4% but I do occasionally get swings as high as 8%. These differences do not track enviornmental conditions like temperature or terrain. So my guess is they're attributable to my driving habit - that is, sometimge I get real aggressive and other times I'm real passive.

 

After four full tanks, I am getting a difference of about 4 to 6 MPG higher showing on the MID vs actual pump measurements.

 

Trust me, most fuel stations aren't honest. I know a few good ones which allways give me a calculated fuel consumption that is equal to the board computer. I know may that each time you fill up, give you a worse calculated average. It's not the Prius's computer.

 

Around here the pumps are measured for accuracy by the government on a yearly or semi-yearly basis. It's the computer.

 

Sho-Bud,

This thread is about the Gen III.

You drive a Gen II Prius. That didn't have a FCD problem. I think it underestimated by 0.1 l/100 or 2-3%.

I'm only on my second Gen III tank and I don't know how full the first tank was delivered by the garage. Real consumption vs computed was 3.9 and 4.27 l/100 km resp. After emptying my 2nd tank I can say more.

 

Our observation is 2% accuracy on the Gen2 and 5% on the Gen3.

Ken@Japan

 

The rental 08 I had was always off 5mpg. After one tank, my 2010 seems to be within 1mpg. But then seriously, does it really make that much of a difference.

 

What is the lifetime difference now?

My most recent fill-up was at 4,999 miles
503.8 miles @ 61.3 (on the MID)
58.4 MPG calculated for a difference of 2.9 MPG or 5.0%
Lifetime at 4,999: 57.0 on MID and 54.3 calculated for a difference of 2.7 MPG or 5.0%

 

glad its not only me...check my sig...last tank difference was 8 MPG...

several times. using 2 different GPS systems, no real differences. over 30 miles one system was .2 miles off, the other dead on.