1. Attachments are working again! Check out this thread for more details and to report any other bugs.

07 Mystery Rattle

Discussion in 'Gen 2 Prius Main Forum' started by 2Touring, Apr 11, 2007.

  1. 2Touring

    2Touring New Member

    Joined:
    Apr 11, 2007
    8
    0
    0
    I have a Touring, purchased in February. I noticed a rattle during the test drive that I figured would be easily tracked down, since it seemed to be something I could almost reach out and touch.
    Well, it's proven to be elusive, and I am hoping perhaps there have been others built by the same guy on the same day.....

    The rattle is generally set off by a sharp jolt, or jittery surface. It seems to be at its worst when temps are in the 40 to 50 degree range. During our few warm days, it was not as apt to occur, and on the colder mornings, in the 20s, it also seemed to be quelled a bit.

    The sound is like that of a loose sun visor rattling, more plastic on plastic or metal, rather than metal on metal. I THINK it is forward of me, yet there are times I swear it is behind me. It's tough to pinpoint since I have been unable to get it to continue more than a second or two. I have removed everything from the rear, and that had no effect, hoping it was something not cinched down properly.

    I've not yet taken it to the dealer, though I think that is inevitable. I'd love to hear from someone who might have encountered something similar, and has been able to rectify it.

    Thanks for any assistance or ideas.
     
    #1 2Touring, Apr 11, 2007
  2. Orf

    Orf New Member

    Joined:
    Mar 11, 2006
    414
    4
    0
    Location:
    Devonport, Tasmania
    Vehicle:
    2009 Prius
    Model:
    N/A
    #2 Orf, Apr 11, 2007
  3. brick

    brick Active Member

    Joined:
    Dec 10, 2006
    1,083
    79
    0
    Location:
    Upstate NY
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    Have you tried removing your sunglasses from the bin above your head?
     
    #3 brick, Apr 11, 2007
  4. 2Touring

    2Touring New Member

    Joined:
    Apr 11, 2007
    8
    0
    0
    <div class='quotetop'>QUOTE(brick @ Apr 11 2007, 10:05 PM) [snapback]421814[/snapback]</div>

    I keep my AARP slipovers on the passenger seat.
    Wish it were that simple
    The CD does slide back and forth in the dash compartment, but that is quiet in comparison.
     
    #4 2Touring, Apr 11, 2007
  5. ibmindless

    ibmindless Member

    Joined:
    Apr 8, 2007
    206
    19
    0
    Vehicle:
    2007 Prius
    Make sure your back seatbacks are firmly locked into the upright position. After I had window tinting installed, I noticed a rattle which seemed to be both in the front and in back. When I climbed in back to look around, I leaned against the seatback and it clicked into the locked position. Case closed.
     
    #5 ibmindless, Apr 11, 2007
  6. Betelgeuse

    Betelgeuse Active Member

    Joined:
    Oct 11, 2005
    1,460
    24
    1
    Location:
    New York, NY, USA
    Vehicle:
    2005 Prius
    Model:
    N/A
    Check in the top dash compartment that the little shelf is properly secured. Or, better yet, take the little shelf out of the glove compartment and see if the noise goes away. You could also make sure that the little shelf in the center console is properly seated.
     
    #6 Betelgeuse, Apr 11, 2007
  7. tbrakel

    tbrakel New Member

    Joined:
    Mar 26, 2007
    1
    0
    0
    <div class='quotetop'>QUOTE(2Touring @ Apr 11 2007, 08:05 PM) [snapback]421779[/snapback]</div>
    I'm not sure the Prius has the same type door pulls as the Ford Escape Hybrid (I need to check my wife's Prius), but I had an elusive rattle that proved to be the inside door pull on the driver's side. There is one small phillips head screw at the base of the plastic "cup". I tightened that and solved the rattle.
     
    #7 tbrakel, Apr 12, 2007
  8. FireEngineer

    FireEngineer Active Member

    Joined:
    Oct 6, 2004
    1,247
    124
    0
    Location:
    SW-Side of Chicago, IL
    Vehicle:
    2010 Prius
    Model:
    IV
    The little triangle windows of the front A-pillars have a plastic vent panel that tends to rattle at times, to see just push down on the panel and see if the rattle stops.

    Wayne
     
    #8 FireEngineer, Apr 13, 2007
  9. V8Cobrakid

    V8Cobrakid Green Handyman

    Joined:
    Jun 6, 2004
    3,790
    152
    0
    Location:
    Park View, Los Angeles, CA. U.S.A
    Vehicle:
    2004 Prius
    Model:
    N/A
    my window switches, a pillar (small triangle piece next to the tiny window), rear view mirror, center speaker, door side arm rest, and door "trim" panels. ( two pieces stuck together...they rattle.

    i can eliminate them all.. but.. I'll wait for dynamat or something
     
    #9 V8Cobrakid, Apr 13, 2007
  10. priussoris

    priussoris New Member

    Joined:
    Apr 5, 2007
    1,005
    4
    0
    we had a light rattle in rear found it was coming from the sliding tarp for lack of a better description.
    the cover you pull back to hide stuff in the hatch area was loose and rattled at times mostly when first start up while vehicle was cold before heater warmed it up,
     
    #10 priussoris, Apr 13, 2007
  11. abq sfr

    abq sfr New Member

    Joined:
    Mar 28, 2007
    690
    3
    0
    Location:
    Albuquerque, NM
    Vehicle:
    2007 Prius
    <div class='quotetop'>QUOTE(Betelgeuse @ Apr 11 2007, 09:09 PM) [snapback]421864[/snapback]</div>
    I'll second this one, I had the same problem! Also had a water bottle in the passenger side door that was rattling.
     
    #11 abq sfr, Apr 13, 2007
  12. 2Touring

    2Touring New Member

    Joined:
    Apr 11, 2007
    8
    0
    0
    I do appreciate all the ideas that have come in. I have checked most of them already. No, this is something else, and when it's discovered, I'll post the findings right away. Today, while driving through the parking lot at work which is quite bumpy in spots, one quick jolt caused the rapping sound to occur four times in rapid succesion. other times, a bump will elicit one rattle or rap. Seems to be more a function of the left side of the car hitting a bump than the right.
     
    #12 2Touring, Apr 13, 2007
(You must log in or sign up to post here.)