1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Ahh! What's Wrong?

Discussion in 'Gen 2 Prius Main Forum' started by john1701a, Feb 28, 2005.

Page 1 of 3
  1. john1701a

    john1701a Prius Guru

    Joined:
    Jan 6, 2004
    12,766
    5,251
    57
    Location:
    Minnesota
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Advanced
    I didn't panic. But I wasn't too thrilled by what I saw. Nothing!

    The distance in the average section of the Consumption Screen was missing. Then it finally appeared. Why? I had no idea. But since the Prius was running just fine, I started my drive home. It really bothered me though. So I tried to switch the Multi-Display over to the Energy Monitor. Nothing. Then a second after I had removed my finger, the button turned green. Then another second later, it switched to that screen. No arrows. No charge-level. Just spinning wheels on the empty template. What the heck?

    I'm a programmer. So debugging a computer problem is no big deal. I tried a few logical things. Turning on the radio via the dashboard button worked fine, and so did adjusting the volume. Nothing appeared on the Multi-Display though. So I started testing the steering-wheel button. Nothing, not even a beep... until I got to the temperature button. One of the last I tried, naturally. The Multi-Display suddenly flashed a "check the status of the air conditioner" message.

    That's it! I suddenly remembered the "Climate" button near the Multi-Display was the last button I had pushed before shutting off the Prius this morning. The screen was acting really, really sluggish... as if it was getting overloaded with input.

    Yup! That was it. The moment I touched the button it became obvious that it was stuck in the pressed position. Sure enough. The moment I released, the Multi-Display snapped back to the fully operational state.

    Phew!
     
    #1 john1701a, Feb 28, 2005
  2. jchu

    jchu New Member

    Joined:
    Mar 2, 2004
    1,063
    0
    0
    Location:
    Nampa, ID
    Actually sounds alot like the intermittant MFD failure that has generated the TSB EL...

    Have been living with the intermitancy for 2 months now while I was out of town living in a hotel room (another story). Had the Prius with me and all systems worked or had a work around for the full 2 months despite the lack of consistant function of the MFD. Due for replacement (finally) this week.
     
    #2 jchu, Feb 28, 2005
  3. 8AA

    8AA Active Member

    Joined:
    Feb 29, 2004
    550
    62
    0
    Location:
    Maryland
    Vehicle:
    2004 Prius
    Glad to hear that it wasn't anything more serious. Hmmm.... frozen buttons, I guess it really does get cold up there in Minnesota. :)
     
    #3 8AA, Feb 28, 2005
  4. efusco

    efusco Moderator Emeritus
    Staff Member

    Joined:
    Nov 26, 2003
    19,891
    1,193
    9
    Location:
    Nixa, MO
    Vehicle:
    2004 Prius
    Model:
    N/A
    Time for the new MFD John.
     
    #4 efusco, Feb 28, 2005
  5. flareak

    flareak Fleet Captain

    Joined:
    Mar 9, 2004
    1,016
    20
    0
    Location:
    St Louis, MO
    Vehicle:
    2005 Prius
    Model:
    N/A
    but... he doesnt need one?
     
    #5 flareak, Feb 28, 2005
  6. john1701a

    john1701a Prius Guru

    Joined:
    Jan 6, 2004
    12,766
    5,251
    57
    Location:
    Minnesota
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Advanced
    Isn't that jumping to a conclusion rather quickly?

    The stuck button observations fit the situation quite well.
     
    #6 john1701a, Feb 28, 2005
  7. efusco

    efusco Moderator Emeritus
    Staff Member

    Joined:
    Nov 26, 2003
    19,891
    1,193
    9
    Location:
    Nixa, MO
    Vehicle:
    2004 Prius
    Model:
    N/A

    Admittedly, yes...but the plethora of similar reports with transient behavior like yours then the next day or next week when it recurred or worsened (like dead MFD) makes me think that's what's up.

    Maybe it really was the stuck button somehow making repeated contact, but that doesn't really make sense to the behavior you described to me. I hope you don't need that...but I also won't be the least bit suprised if you come back in a day or a week with a completely non-functional display.
     
    #7 efusco, Feb 28, 2005
  8. hdrygas

    hdrygas New Member

    Joined:
    May 22, 2004
    3,650
    6
    0
    Location:
    Olympia Wa
    Vehicle:
    2004 Prius
    John have you been driving around with sticky stuff on your hands, honey, ice cream, candy or the like? Any one spill soda on the buttons. Got kids?
     
    #8 hdrygas, Feb 28, 2005
  9. ALoLA

    ALoLA New Member

    Joined:
    Apr 8, 2004
    113
    0
    0
    Location:
    Southern California
    Vehicle:
    2004 Prius
    He will soon enough. That's how mine started. No problems since getting the MFD replaced though. :)
     
    #9 ALoLA, Mar 1, 2005
  10. Darwood

    Darwood Senior Member

    Joined:
    Feb 21, 2005
    5,259
    268
    1
    Location:
    Minnesota
    Vehicle:
    2010 Prius
    Model:
    N/A
    I am curious about the MFD problem. How long is the MFD covered by warranty? 36K, 60K, or 100K? What model years is it a common problem? Is it a "wear" problem that they might then claim is not covered by warranty? How much would a replacement cost if it was beyond the warranty?

    I have a new 05 with 1000 miles on it and did not purchase the extended warranty (a wise move as they wanted $1650). But I am considering buying it here, but plan on waiting a year or so to pull the trigger. The MFD problem might fully convince me to get it.
     
    #10 Darwood, Mar 1, 2005
  11. finman

    finman Senior Member

    Joined:
    Apr 9, 2004
    1,287
    111
    0
    Location:
    Albany, OR
    Vehicle:
    2014 Nissan LEAF
    The MFD is under the 36K warranty. Swapped out with a refurb would set u back about $400 (if out of warranty). This is per my dealer. I had the same symptoms and had it replaced last week. Cold weather would cause it to be intermittent, then as the heater warmed the car the functions would start working. Took 5 days to get the part, about 30 min to replace. All warranty, no hassles. Drive fun, drive clean, drive Prius!
     
    #11 finman, Mar 1, 2005
  12. TonyPSchaefer

    TonyPSchaefer Your Friendly Moderator
    Staff Member

    Joined:
    May 11, 2004
    14,816
    2,498
    66
    Location:
    Far-North Chicagoland
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Advanced
    Not as long as he doesn't use the A/C. :)
     
    #12 TonyPSchaefer, Mar 1, 2005
  13. jchu

    jchu New Member

    Joined:
    Mar 2, 2004
    1,063
    0
    0
    Location:
    Nampa, ID
    Actually, I was able to run the heater from the steering wheel while in Seattle for 2 montths while mine was out . Just couldn't control which vents or tell what temp I had it set at. As it turns out, after dealing with it for 2 months, a misbehaving MFD is annoying but not incapacitating.
     
    #13 jchu, Mar 1, 2005
  14. DanMan32

    DanMan32 Senior Member

    Joined:
    Aug 27, 2004
    3,799
    27
    0
    Location:
    Tampa Bay, FL
    Unless the defective MFDs were really defective buttons getting stuck, with the buttons progressively getting worse.

    But then, the symptoms correlated to cold temps.

    John, what was the production month of your car? Does the info button on steering wheel toggle between energy and consumption screens?
     
    #14 DanMan32, Mar 1, 2005
  15. efusco

    efusco Moderator Emeritus
    Staff Member

    Joined:
    Nov 26, 2003
    19,891
    1,193
    9
    Location:
    Nixa, MO
    Vehicle:
    2004 Prius
    Model:
    N/A
    Dan, he's got a very early model...I believe he picked it up Oct. 17 or 19, 2003.
     
    #15 efusco, Mar 1, 2005
  16. PNeu

    PNeu New Member

    Joined:
    Jul 1, 2004
    11
    0
    0
    I have similar problems since November last year. All the same but what's most annoying is on/off radio (JBL). I have to push FM button to turn it on every 2-3 minutes or drive in silence, which sometimes is just FINE with me :)

    Toyota diagnosed MFD malfunction, ordered new unit, five weeks and still counting.

    Stuck button? Wishful thinking, I'm afraid.

    Welcome to the "TSB EL002-05" Club, Padre!
     
    #16 PNeu, Mar 1, 2005
  17. john1701a

    john1701a Prius Guru

    Joined:
    Jan 6, 2004
    12,766
    5,251
    57
    Location:
    Minnesota
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Advanced
    What does MFD actually mean?

    In other words, what physical parts?

    Since there were many misdiagnoses with the Classic model, where the solution was to just blindly replace all related components, I don't believe any claims without detail. Grouping them all together isn't helping anyone.

    For example, what actually failed?

    In my case, the Multi-Display itself has worked flawlessly, as well as all the steering-wheels button to interface with it. So that would isolate the problem to either the other buttons or the interface with them. And of course, it cannot even be counted as a problem until it occurs a second time.

    Please provide details & links.
     
    #17 john1701a, Mar 1, 2005
  18. PNeu

    PNeu New Member

    Joined:
    Jul 1, 2004
    11
    0
    0
    #18 PNeu, Mar 1, 2005
  19. john1701a

    john1701a Prius Guru

    Joined:
    Jan 6, 2004
    12,766
    5,251
    57
    Location:
    Minnesota
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Advanced
    That TSB confirms what I already said... they do "blanket" fixes at first.

    And how many times must y'all read the words MULTI-DISPLAY before you finally stop calling it MFD? After all, that is a terrible abbreviation for "Multi-Informational Display", as it is referred to in the owner's manual.

    I'll keep an eye out now for reoccurences. Since I debug software professionally, the solution to "just replace it" is not one I choose to accept easily. I need to know why.
     
    #19 john1701a, Mar 1, 2005
  20. bigbaldcuban

    bigbaldcuban New Member

    Joined:
    Feb 16, 2004
    599
    1
    0
    Location:
    Mansfield, TX
    Gremlins. Filthy little gremlins.
     
    #20 bigbaldcuban, Mar 1, 2005
(You must log in or sign up to post here.)
Page 1 of 3