1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Shaking when ICE kicks in

Discussion in 'Gen 4 Prius Care, Maintenance and Troubleshooting' started by Aadilish, Jan 29, 2024.

  1. Aadilish

    Aadilish Junior Member

    Joined:
    Jun 19, 2021
    5
    2
    0
    Location:
    DUBAI
    Vehicle:
    2018 Prius
    Model:
    Four Touring
    I have a 2017 prius with about 42k miles on it. My wife drove it through a puddle about a couple of months ago. The engine light came on. I was traveling so I asked her to park the prius and drive the other car. When I got back 10 days later I could feel moisture in the floor mats and the check engine light was on. I started the car and drove it about 50 miles and the engine light went away. However, I could feel a shudder/shake everytime the engine would kick in especially if you keep a light foot on the gas.. With a light foot it is a sustained shake. If you accelerate hard, the shake goes away. There is zero shake whe the car is running on electric motor. I have also notices that the shake is minimal when the car is cold. The translation from ICE to electric and back is smooth. I took the car to a local garage. The plugs got replaced, coils are also fine, air filter replaced. They even opened the inspected the transmission damper but no issues were detected. There are no error messages when you put the scanner in. Any idea what might be the cause? Thanks
     
    #1 Aadilish, Jan 29, 2024
  2. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    110,133
    50,050
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    how is the engine coolant level?
     
    #2 bisco, Jan 29, 2024
  3. BiomedO1

    BiomedO1 Senior Member

    Joined:
    Mar 27, 2021
    1,835
    930
    0
    Location:
    SacTown, Ca
    Vehicle:
    2021 Prius Prime
    Model:
    LE
    Check the fuel trims and temperature sensors for proper operations. The CEL should be in your scan tool history, see what code was initially tripped - that may give you a clue to what's going on. Or you may just have a bad tank of fuel - dump some injection cleaner in the tank and see what happens.
     
    #3 BiomedO1, Jan 29, 2024
  4. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    24,906
    16,213
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    The shaking at moderate load, not at heavy load and not at idle, can be a strong suggestion to clean the small EGR passages found in the intake manifold.
     
    #4 ChapmanF, Jan 29, 2024
  5. Aadilish

    Aadilish Junior Member

    Joined:
    Jun 19, 2021
    5
    2
    0
    Location:
    DUBAI
    Vehicle:
    2018 Prius
    Model:
    Four Touring
    Steady no visible loss over the last 2 months

    Steady level. Have observed no reduction.. tx

    Coolant level steady and no reduction observed.
     
    #5 Aadilish, Jan 30, 2024
    Last edited by a moderator: Jan 30, 2024
  6. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    110,133
    50,050
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    Odd for 42k
     
    #6 bisco, Jan 30, 2024
  7. vvillovv

    vvillovv Senior Member

    Joined:
    Mar 19, 2013
    3,901
    1,338
    1
    Location:
    NY
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Plus
    :coffee:
    A puddle ?
    carpet was wet?
    is the carpet dry now?
    2011 Throwing Codes After Driving Through Puddle | PriusChat
     
    #7 vvillovv, Jan 31, 2024
  8. Aadilish

    Aadilish Junior Member

    Joined:
    Jun 19, 2021
    5
    2
    0
    Location:
    DUBAI
    Vehicle:
    2018 Prius
    Model:
    Four Touring
    Thank you. Have checked plugs, coils and all relevant sensors still the same. As a last resort, am have the ecm looked at for potential transistor misbehavior. Will update ASAP. Thank you for your inputs
     
    #8 Aadilish, Feb 8, 2024
    vvillovv likes this.
  9. Aadilish

    Aadilish Junior Member

    Joined:
    Jun 19, 2021
    5
    2
    0
    Location:
    DUBAI
    Vehicle:
    2018 Prius
    Model:
    Four Touring
    Adeendum: The shaking clearly is on account of engine misfiring at low rpms.. unfortunately it is at the sweet spot where all the gas savings are. If you keep rpms high misfiring disappears ....will update soon. Thanks again
     
    #9 Aadilish, Feb 9, 2024
    vvillovv likes this.
  10. vvillovv

    vvillovv Senior Member

    Joined:
    Mar 19, 2013
    3,901
    1,338
    1
    Location:
    NY
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Plus
    If you are able to post and Diagnostic Trouble Codes specific to your Prius issues, that could help us reading your thread understand, why the puddle and wet carpeting observations lead to the misfire at optimal RPM and disappearing at higher RPM.
    If it's extra work or worry, please don't feel obligated in any way.

    And thank you for updating your thread with what you have already learned.
     
    #10 vvillovv, Feb 10, 2024
    Last edited: Feb 10, 2024
  11. Mendel Leisk

    Mendel Leisk EGR Fanatic

    Joined:
    Oct 17, 2010
    56,674
    39,222
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Try cleaning the intake manifold?

    Note, in the attached, Toyota doesn't make any mention of of torque for throttle body hold-down nuts/bolts. FWIW, for 3rd gen the value is 7 lb/ft.
     

    Attached Files:

    #11 Mendel Leisk, Feb 11, 2024
    Last edited: Feb 11, 2024
(You must log in or sign up to post here.)