1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Ticking or clicking noise during braking

Discussion in 'Gen 4 Prius Care, Maintenance and Troubleshooting' started by glennonrp, Mar 13, 2017.

  1. glennonrp

    glennonrp Active Member

    Joined:
    Jan 31, 2016
    178
    199
    0
    Location:
    Fontana, CA
    Vehicle:
    2016 Prius
    Model:
    Four Touring
    Lately I'm noticing a ticking noise or clicking noise as I slow to a stop. I can only hear it at low speeds and it goes away when I take my foot off the brake pedal or when I stop. The ticking slows down as the car's velocity slows, too.

    Is this normal? I have 12K miles on the car and have had it just over 12 months now.


    iPhone ?
     
    #1 glennonrp, Mar 13, 2017
  2. robsnyder20

    robsnyder20 Active Member

    Joined:
    Aug 13, 2012
    374
    301
    0
    Location:
    SW Florida USA
    Vehicle:
    2016 Prius
    Model:
    Three
    Check out this thread: Clicking Sound on Regen Braking | PriusChat I am gonna have mine checked out at the dealer as mine started shortly after the 5K service
     
    #2 robsnyder20, Mar 13, 2017
    RCO and glennonrp like this.
  3. sillymike

    sillymike Junior Member

    Joined:
    May 18, 2010
    59
    21
    0
    Location:
    GA
    Vehicle:
    2021 Prius Prime
    Model:
    Limited
    Took my 2017 Prius 4 touring in for 25k service today and I have the same noise. After 2 other attempts of them not being able hear the noise they finally did today. They are going to replace the front axle!!!! I am concerned they may not put everything back in place or it may cause future problems. I think its the brake actuator but they think its more serious.
     
    #3 sillymike, Mar 27, 2018
  4. Erik Owens

    Erik Owens Member

    Joined:
    Mar 25, 2018
    162
    59
    0
    Location:
    Florida
    Vehicle:
    2010 Prius
    Model:
    Three
    I have a 2016 that we are trying to figure out what the same noise is. Its only when going straight and braking at low speeds which could be up to 35 mph to 14 mph. If you put it neutral at the same speed and brake going straight it goes away which tells us it is high suspicious of a CV Axle joint. It sucks too because you cant reproduce the issue on the lift because geometry changes of everything with weight off. I ordered one for our vehicle doing the same clicking rapidly or if in the vehicle windows up sounds like a ratcheting noise like a playing card in bicycle wheel as one customer put it.
     
    #4 Erik Owens, Mar 27, 2018
    Marcius likes this.
  5. Erik Owens

    Erik Owens Member

    Joined:
    Mar 25, 2018
    162
    59
    0
    Location:
    Florida
    Vehicle:
    2010 Prius
    Model:
    Three
    The clicking ratcheting noise was the LF CV Axle. Ive seen posts that call out one or the other but it transmits through the wheel pretty good so if you here it slightly inside the cabin you or a friend should be able to hear it pretty well and more so from the outside of the vehicle almost right by or in the wheel area.
     
    #5 Erik Owens, Mar 28, 2018
    Rickyedger, RCO and sillymike like this.
  6. glennonrp

    glennonrp Active Member

    Joined:
    Jan 31, 2016
    178
    199
    0
    Location:
    Fontana, CA
    Vehicle:
    2016 Prius
    Model:
    Four Touring
    As a follow up, my dealer replaced the axle a couple weeks ago to fix this. So far so good.
     
    #6 glennonrp, Mar 30, 2018
    RCO likes this.
  7. Jesse R.

    Jesse R. New Member

    Joined:
    Sep 16, 2020
    1
    0
    0
    Location:
    las vegas
    Vehicle:
    2017 Prius
    Model:
    Four Touring
    Toyota technical service bulletin located below :) best of luck!

    T-SB-0157-18
     
    #7 Jesse R., Sep 16, 2020
  8. KoWee74

    KoWee74 New Member

    Joined:
    Sep 30, 2020
    2
    0
    0
    Location:
    Budapest - Hungary
    Vehicle:
    2016 Prius
    Model:
    N/A
    After one year struggling, problem solved. Because my car passed the 60k miles, I should pay 710 USD + labour cost for the shaft replacement, so first I tried to solve myself. I have removed the boot from the LF joint outer boot, and the grease was much softer than I saw in other cars. Actually it leaked out from the rubber boot. So I cleaned up the old grease, the joint washed perfectly and filled up with normal joint grease. The clicking sound gone, so far so good.
     
    #8 KoWee74, Sep 30, 2020
(You must log in or sign up to post here.)