smoothness of engine on/off transitions?

sounds about right, gen 3 is a little smoother. plus mileage matters.

 

That's normal. I remember that change. The reconfigure of the power-split-device along with the introduction of a two-speed setup (another PSD instead of a reduction-gear) made it smoother.

 

That is normal. I'm the original owner of a 2004, and it has been doing that all along. The only time it is really noticeable to me is when the vehicle is stopped. I have driven a couple of other cars (conventional, not hybrid) that have the engine stop when the vehicle is stopped for more than a few seconds, and they make the same type of shudder.


-Graeme-
2004 Prius with >190,000 miles.
Sent ?.

 

A "weak" 12 V battery is something that MUST be corrected ASAP. Otherwise you may go out some morning soon and find the car totally dead. (Like I did about 6 or 7 years ago.)

Of course, Toyota in their wisdom made the battery a non-standard size, with non-standard size terminals, and with an electrolyte vapor exhaust tube that must be connected. (That's because it is inside the vehicle instead of in the engine compartment.) I have taken the easy way out and had the dealer do it. My car is on its third one now. (Note: the first time that battery died it had to be towed. The last time I had the dealer replace it when the car was there for something else.)




-Graeme-
2004 Prius with >190,000 miles.
Sent ?.

 

Question about when your 12v battery died, if you had a new battery and brought it to ur prius and swapped it out then and there, it would have turned on fine and you could have drove right away?

 

you're feeling it on the older car because the engine and transmission are attached via 3 rubber mounts. As these age, the rubber softens and breaks down, and allows the engine to rock when it starts. try new engine mounts and you will be amazed at the difference.

 

I have no idea. In any case, with the car inoperable, I had no way to get anywhere except by hoofing it.

-Graeme-
2004 Prius with >190,000 miles.
Sent ?.

 

Interesting - thanks. I will look into that. (40 to 50 years ago I would have done that work myself. Not any longer ...)


-Graeme-
2004 Prius with >190,000 miles.
Sent ?.

 

correct

 

I had this happen on mine. It got more and more "shuddery" to the point that it wouldn't restart sometimes (like at a light) and would throw a code for the throttle position sensor. In that instance my shade tree mechanic swapped the throttle assembly (?) for another one we had on hand and it cleared right up. 50k miles later (this car has 380,000 miles, 2nd engine, and a replaced new hybrid pack) it started getting rough again (no codes) so I had him clean the throttle body really good and it smoothed out.

I'm not a mechanic. I have one. But I've put hundreds of thousands of miles on three different Gen II's. There are normal noticable transitions then there are "that doesn't sound right" engine transitions. I would think about cleaning the throttle body if it gets bad. Just my 2 cents.