1. Attachments are working again! Check out this thread for more details and to report any other bugs.

unexplained engine racing

Discussion in 'Gen 3 Prius Technical Discussion' started by akbetts, Sep 19, 2011.

  1. akbetts

    akbetts Junior Member

    Joined:
    Sep 17, 2011
    7
    8
    0
    Location:
    Vermont
    Vehicle:
    2010 Prius
    Model:
    Two
    Our 2010 Prius with 33000 miles has developed strange 'engine racing'. At low speeds around 20-30mph, (warm) engine will rev up for 10+ sec with no foot on brake or accelerator. Then engine warning light comes on. Toyota dealer says "lean code", cleaned MAF sensor, checked AF and O2 sensors - OK. But same behavior continues- engine warning light back on. Otherwise runs normal. Any ideas?
     
    #1 akbetts, Sep 19, 2011
  2. Teakwood

    Teakwood Member

    Joined:
    Jun 23, 2010
    491
    73
    0
    Location:
    New Mexico
    Vehicle:
    2010 Prius
    Model:
    II
    Take it to a different dealer.
    If the warning light is coming on, there has got to be something wrong.
     
    #2 Teakwood, Sep 19, 2011
  3. Gary Otto

    Gary Otto Member

    Joined:
    Jul 17, 2011
    123
    19
    0
    Location:
    Silver Springs, FL
    Vehicle:
    2011 Prius
    Model:
    Four
    Maybe a fuel filter problem causing it to be lean. A dirty air filter would choke it and cause a rich condition.

    You have had alot of rain there....maybe water has seeped into an underground tank and contaminated the fuel.

    I'm sure Toyota dealers are few and far between there in VT.
     
    #3 Gary Otto, Sep 19, 2011
  4. F8L

    F8L Protecting Habitat & AG Lands

    Joined:
    Aug 14, 2006
    19,011
    4,081
    50
    Location:
    Grass Valley, CA.
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    My first thought is you are reaching a maximum state of charge. In this situation, the engine will rev up to bleed off excess power yet there is no change in traveling speed. This is completely normal. Your situation may be different though as there is a warning light which wouldn't happen in the above scenario.
     
    #4 F8L, Sep 19, 2011
  5. GrumpyCabbie

    GrumpyCabbie Senior Member

    Joined:
    Dec 14, 2009
    6,722
    2,121
    45
    Location:
    North Yorkshire, UK
    Vehicle:
    2010 Prius
    Model:
    III
    Is the a/c on?
    Has the vehicle been in an accident or more importantly, a flood?
    Is the cat converter ok?
    Has the car been correctly serviced and if so by who and is there proof?
     
    #5 GrumpyCabbie, Sep 19, 2011
  6. akbetts

    akbetts Junior Member

    Joined:
    Sep 17, 2011
    7
    8
    0
    Location:
    Vermont
    Vehicle:
    2010 Prius
    Model:
    Two
    Dealer mentioned this possibility and said add dry gas - I did and saw no impact.

    Others asked
    Who serviced? - Toyota dealer in Rutland VT.
    A/c not on
    Problem basically when car is coasting

    thanks for your help!
     
    #6 akbetts, Sep 19, 2011
  7. akbetts

    akbetts Junior Member

    Joined:
    Sep 17, 2011
    7
    8
    0
    Location:
    Vermont
    Vehicle:
    2010 Prius
    Model:
    Two
    No accident
    No flood - been housed in garage
    Serviced on scheduled by Toyota dealer we have been going to for 6 years - 2005 prius and this 2010
     
    #7 akbetts, Sep 19, 2011
  8. xpcman

    xpcman Senior Member

    Joined:
    Jun 11, 2009
    1,302
    295
    0
    Location:
    California - SF Bay area
    Vehicle:
    2008 Prius
    A dirty AIR filter may cause a loss in performance, but, it can't cause a "rich condition" in a Prius. The MAF sensor will balance the ratio of gas to air flow.
     
    #8 xpcman, Sep 19, 2011
  9. pjksr02

    pjksr02 Active Member

    Joined:
    Nov 2, 2009
    532
    225
    2
    Location:
    Connecticut
    Vehicle:
    2010 Prius
    Model:
    III
    You could try running a good fuel system cleaner, like Chevron's Techron or Seafoam, to reduce potential injector blockage.

    Did they tell you the code number you have, or just say "lean code?"
     
    #9 pjksr02, Sep 23, 2011
  10. akbetts

    akbetts Junior Member

    Joined:
    Sep 17, 2011
    7
    8
    0
    Location:
    Vermont
    Vehicle:
    2010 Prius
    Model:
    Two
    Re: unexplained engine racing/vacuum-switching-valve failure

    Dealer found problem after two frustrating weeks of confusing codes, and car finally shutting down only a few hundred yards from dealer. Problem was
    1) Vacuum switching valve was stuck open
    2) This appeared to to have loosened a vacuum line.

    Result was a range of lean code, evap codes, MAF code(PO101); PO440 (incorrect purge flow), PO445 (gross leak detected), and presumably the racing engine that I noticed.
    Thanks to those who made suggestions- hope this helps others!
     
    #10 akbetts, Oct 2, 2011
    6 people like this.
(You must log in or sign up to post here.)