1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Annoying fluttering sound from ventilation fan

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by Sun Lion, Jun 14, 2021.

Tags:
  1. Sun Lion

    Sun Lion New Member

    Joined:
    Jun 14, 2021
    1
    0
    0
    Location:
    California
    Vehicle:
    2007 Prius
    Model:
    N/A
    Hi there!

    My Gen 2 Prius has just recently begun making an annoying fluttering sound when the climate system is in use.

    At low speeds the noise is slower, and at higher speeds the noise is faster. It only stops if I turn off the climate system.
    ​
    I removed the glove box to see what I could find, as well as to replace the cabin air filter. Upon further inspection, the fluttering noise is from the spinning component of the fan.

    ​
    Video


    Any ideas on what to be done to make the noise go away?

    I'm wondering if the spinning part just needs to be replaced due to perhaps the bearings being shot? If so, I may need to take it into a shop for that as it seemed tricky to get that component in/out.​

    Thanks so much for your help and guidance!!


    PS, this is my first post! What an amazing community of resource here :) Grateful.
     
    #1 Sun Lion, Jun 14, 2021
  2. rjparker

    rjparker Tu Humilde Sirviente

    Joined:
    Jun 6, 2008
    8,493
    5,057
    7
    Location:
    Texas Hill Country
    Vehicle:
    2012 Prius v wagon
    Model:
    Three
    I would try a can of ac coil cleaner injected from the condensate drain.
     
    #2 rjparker, Jun 15, 2021
  3. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    110,133
    50,050
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    are you sure there isn't any debris in between the fan blades and the sides?
     
    #3 bisco, Jun 15, 2021
  4. sam spade 2

    sam spade 2 Senior Member

    Joined:
    Mar 31, 2018
    7,035
    2,790
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    WHAT ??
    That makes no sense at all.
     
    #4 sam spade 2, Jun 15, 2021
  5. mr_guy_mann

    mr_guy_mann Senior Member

    Joined:
    Sep 3, 2020
    3,668
    1,715
    0
    Location:
    NJ-USA
    Vehicle:
    2006 Prius
    Model:
    Four
    My first thought is that some sort of debris made it past the cabin air filter and is now "stuck" in the fan/ blower. Usually isn't too difficult to remove the blower motor assembly, clean it out, and put it back.

    Posted via the PriusChat mobile app.
     
    #5 mr_guy_mann, Jun 15, 2021
  6. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,525
    8,428
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    I would reach my hand in the fan and see if I can clear out some debris.

    Alternatively you can remove the fan and just clean it out completely.
     
    #6 JC91006, Jun 15, 2021
  7. pasadena_commut

    pasadena_commut Senior Member

    Joined:
    May 2, 2019
    1,713
    516
    0
    Location:
    Southern California
    Vehicle:
    2007 Prius
    Model:
    N/A
    It does sound quite a bit like a worn fan bearing to me. With the car completely off see if you can give one of the blades a good push with a finger to set it spinning. If the bearing is in good shape it should spin for a "reasonable" time (at least many seconds) with little or no noise. If it stops rapidly, especially if it doesn't even complete one turn, or is noisy then it is most likely the bearing. To do that test you will need to pull out the filter.



    Also see:
     
    #7 pasadena_commut, Jun 15, 2021
  8. fotomoto

    fotomoto Senior Member

    Joined:
    Apr 22, 2009
    5,608
    3,788
    0
    Location:
    So. Texas
    Vehicle:
    Other Hybrid
    My original gen1 RAV4 would suck in napkins from the glove box if they were left loose on top of all the other things.
     
    #8 fotomoto, Jun 15, 2021
  9. Krokettenslayer

    Krokettenslayer Junior Member

    Joined:
    Aug 8, 2020
    12
    2
    0
    Location:
    Netherlands
    Vehicle:
    2006 Prius
    Model:
    Business Edition
    Did the sound start gradually or did it happen all of a sudden? If so I would suggest using one of these to vacuum out any debris that could have fallen next to the fan.
     

    Attached Files:

    #9 Krokettenslayer, Jun 16, 2021
  10. Mendel Leisk

    Mendel Leisk EGR Fanatic

    Joined:
    Oct 17, 2010
    56,675
    39,222
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Mice?
     
    #10 Mendel Leisk, Jun 16, 2021
  11. dolj

    dolj Senior Member

    Joined:
    May 14, 2012
    7,855
    3,967
    0
    Location:
    Wellington, New Zealand
    Vehicle:
    2007 Prius
    Model:
    N/A
    If it were mice, I'd have thought it would be more of a squeak, no?
     
    #11 dolj, Jun 17, 2021
    Mendel Leisk likes this.
  12. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    24,906
    16,213
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    When my dad's Hyundai had a mouse nest in the fan, it shook the whole dash like an unbalanced washing machine.
     
    #12 ChapmanF, Jun 17, 2021
(You must log in or sign up to post here.)