1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Burning smell

Discussion in 'Gen 3 Prius Technical Discussion' started by bnaccs, Nov 2, 2011.

  1. bnaccs

    bnaccs bnaccs

    Joined:
    Dec 9, 2007
    191
    10
    1
    Location:
    Colorado
    Vehicle:
    2010 Prius
    Model:
    III
    I just drove my Prius through 8-10 inches of heavy wet snow. The car did amazingly well. At times my traction control light was on when trying to get up an incline until the car got going. Then when I got home I stopped in my driveway for the garage door to open and started into the garage. The car was stuck, but then the light came on and the car climbed the driveway in about 10-15 seconds and made it in the garage. I then noticed a smell like burning tires. Maybe it was the tires from spinning. I hope that I didn't hurt my transmission or another component. Does the Prius protect iteself if it is stuck and the traction control light is on from overheating something? I think I recall that the 2nd generation Prius would not allow for wheel spin to protect the traction battery.

    By the way, I did notice that using eco-mode really helps eliminate wheel spin.
     
    #1 bnaccs, Nov 2, 2011
  2. spiderman

    spiderman wretched

    Joined:
    Jul 5, 2009
    7,543
    1,558
    0
    Location:
    Alaska
    Vehicle:
    2010 Prius
    Model:
    II
    I am guessing the inverter was warm/hot. After a road trip this summer, with some mountain climbs and with grill blocking in, I smelled something burning/hot too.
     
    #2 spiderman, Nov 2, 2011
  3. David Beale

    David Beale Senior Member

    Joined:
    Jul 24, 2006
    5,963
    1,985
    0
    Location:
    Edmonton Alberta
    Vehicle:
    2012 Prius
    Most likely the tires you smell. Even spinning on snow will generate a smell (but no smoke ;) ). I haven't hurt the car spinning the tires (as much as it lets me) in four winters of driving. And I can tell you we certainly have lots of snow/ice to drive on!

    Do note that for the first year or two when you get the lower cases of the engine/HSD warm you will smell the wax they spray on for shipping. It may be more noticeable when in cold air.
     
    #3 David Beale, Nov 2, 2011
  4. Chazmann

    Chazmann Junior Member

    Joined:
    Nov 7, 2011
    19
    3
    0
    Location:
    Los Angeles
    Vehicle:
    2020 Prius Prime
    Model:
    Plug-in Advanced
    If the smell was not from the tire spinning/burining, it could have been from the CVT system, like belt slipping between the coverter sheaves.

    Shown below is a typical CVT system but not from Prius obviously.

    [​IMG]
     
    #4 Chazmann, Nov 10, 2011
  5. qbee42

    qbee42 My other car is a boat

    Joined:
    Mar 2, 2006
    18,058
    3,075
    7
    Location:
    Northern Michigan
    Vehicle:
    2006 Prius
    The Prius does not have a belt or pulleys. The transmission of the Prius is not a mechanical CVT. The mechanical portion has fixed gearing; not shiftable, no clutch, no pulleys, no shift bands. Only the electrical power path is variable.

    Tom
     
    #5 qbee42, Nov 10, 2011
  6. cit1991

    cit1991 New Member

    Joined:
    Apr 5, 2010
    289
    95
    0
    Location:
    Tulsa, OK
    Vehicle:
    2010 Prius
    Model:
    IV
    The TCS uses differential braking to control wheel slip. If one wheel slips and the other isn't, the open diff will prevent torque from going to the wheel that's not slipping, which is bad, since that one has traction.

    The TCS will brake the spinning wheel, so the wheel with traction can get torque and pull the car forward.

    With all the struggling you did, it was probably doing braking like this and heated up the rotors, and burnt off some dirt.
     
    #6 cit1991, Dec 9, 2011
(You must log in or sign up to post here.)